Today’s contestants: the lovely and talented Sony 16mm f/2.8 and Olympus 17mm f/2.8 pancake lenses.
Since everyone seemed to enjoy looking inside an NEX mirrorless camera, I decided to take more pictures while doing today’s disassembly.
Optically I expected both lenses to be fairly simple: the Sony has 5 single elements, the Olympus 6 elements in 4 groups, and both have the diaphragm about in the center of the lens elements. They seem very similar as we start opening up the backs: both have 3 screws holding in a light baffle / protection cap, and 4 screws holding on the lens mount, just like most other lenses.
The Olympus (left) and Sony lenses with backs removed.
There are a couple of minor differences: the Olympus only uses 1 small screw to hold its electronic connector to the mount, while the Sony uses two. It’s at this point that we found the first (and apparently only) optical adjustments. The Olympus uses washer type shims, while the Sony uses some 90 degree shims (black and white things in the picture) to space the lens-to-lensmount interface.
Removing the PC boards is more of the same, again Sony uses 3 screws (I have no idea why, no one else does) to hold the board in place, while the Olympus goes with the more common single screw.
Olympus Disassembly
At this point, disassembly of the two lenses gets a bit different. It’s obvious in the above picture that the Olympus has several screws holding the optical assembly in the case. Take those out and slip the case off . . .
Then turn it over, pop off the plastic front makeup ring, remove the couple of screws revealed under the makeup ring . . .
. . . . and the rest of the front rings come off, leaving the core of the lens completely uncovered.
Largely disassembled Olympus pancake (rear view). Note the focusing motor at bottom and geared teeth engaging from manual focusing ring. Smaller motor at 11 O’clock is the aperture control motor.
Two screws remove the focusing motor. The aperture control motor slips out and its flex disconnects, and now the optical elements are separated from most of the lens. The Olympus design places the optical elements in the center of a 3-armed plastic piece that connects the lens ring. Olympus optical elements and array, with aperture motor removed. You can recognize the purple ring and see the 5 bladed aperture, but that’s about all that lets you know this was the Oly.
The entire optical assembly slides back and forth on three arms within the outer ring for focusing. With a prime lens this small there’s no need for a separate focusing element.
The plastic mount for the lens core had a couple of lensmaker’s marks on it. I had hoped, as is often the case, they would be associated with adjusting shims or collars, but I certainly couldn’t find any. Whether the marks are some directions for orienting this assembly, somebody’s signature, or random graffiti I don’t know. Maybe one of you can tell me?
Sony Disassembly
Sony disassembly was initially less obvious. After the PC board was removed I had expected the front plastic makeup ring to pop off, like most do, but it wasn’t budging. Re-examination didn’t reveal any other way in so I tried popping the front makeup ring a little harder. This sort of worked, although it ruined the makeup ring. It turns out Sony holds it down with a ton of glue, rather than plastic pop-tabs like most lenses. Oh, well, next time I’ll know to use glue remover. But once the ring was removed the barrel pieces slip right off the lens.
Here’s the front of the Sony pancake lens with most of barrel removed. Torn up makeup ring and glue residue on plastic around the lens demonstrate this was obviously my first time opening one of these.
The lens core lifts out of the bottom case and has three screws begging to be removed . . .
. . . which lets us remove the inner optical core from the surrounding support.
Once past the front makeup ring, the Sony disassembly was quick and easy.
Having removed all the lens parts except the optics, the two lenses look rather different: the Sony has a small, self contained optical assembly while the Olympus assembly is mounted to three arms that slide up and down through an outer ring.
Olympus (left) and Sony (right) optical cores.
The optical groups of both lenses, however, can be separated into front and rear components by removing a couple of screws. With the Sony lens removing the screws visible in the photo above allows the diaphragm assembly comes out as a separate piece (left side of each image below), sandwiched between the front (upper image) and rear (lower image) glass elements of the lens.
The diaphragm unit of the Sony lens, with the front (upper) and rear (lower) optical components.
With the Olympus, removing the screws allows most of the optics to detach in a group, with only one element remaining in the center of the plastic arms.
I had expected to see a shim or adjustment here, but there wasn’t one. Nor was there one in the Sony. So as best I can determine, both of these pancake lenses have no real optical adjustments other than shims at the lens mount. But then, pancakes aren’t generally expected to be razor sharp lenses.
The remaining optical section of the Olympus (left side in above image) separates neatly in two halves at the aperture. Unlike the Sony, the aperture unit isn’t self contained, but rather sits on top of the rearward group. This allowed for a nice demonstration of how aperture blades are set up (in case you haven’t seen it before). The right side image below shows the two rings of the aperture mechanism, with mounting posts on both the outer and inner rings. The aperture blades (one is sitting above the lens in the right illustration) mount to the outside post at the hole in one end, and the slot fits over the post on the inner ring. As the inner ring is turned in relation to the outer ring, the post moves along the slots, closing or opening the aperture.
The Final Images
Of course, I have to post the images of the disassembled lenses, first the Olympus and then the Sony:
Completely disassembled Olympus 17mm f/2.8 m4/3 pancake lens.
Completely disassembled Sony 16mm f/2.8 E-mount pancake.
These are the smallest and simplest lenses I’ve ever taken apart. The front element of a 70-200 f/2.8 lens is larger and heavier than either of these. The small size of the glass elements is really shocking: even the rear element of, say, a 50mm f/1.4 lens contains more glass than all the elements in either of these. Despite the fact it has to cover a larger sensor, the elements in the Sony lens aren’t obviously larger than those in the Olympus.
The simplicity of the design shows why these lenses rarely break. And since optical adjustment isn’t an option, apparently, there won’t be a lot of reason for me to do this again. Which is too bad, really. It’s a nice, straightforward disassembly, with a simple internal design.
And before someone asks: yes, I can put them back together. [gizmodo]
Dr. Roger Cicala is the founder of Lensrentals.com. Since the company has long since outgrown his ability to manage it, he is now the Director of Research and Quality Assurance for Lensrentals, meaning he spends all day taking photography things apart and figuring out how they work.
3,309 comments
texas driver education says:
November 29, 2012 at 11:10 am (UTC -4)
texas driver education…
[...]we came across a cool website which you could delight in. Take a look should you want[...]…
cupon hostgator says:
November 29, 2012 at 2:53 pm (UTC -4)
Resources Of Great Info…
[...]great resource of info about[...]…
casino usa says:
November 29, 2012 at 2:59 pm (UTC -4)
casino usa…
[...]one of our guests recently recommended the following website[...]…
Sail Croatia says:
November 29, 2012 at 6:30 pm (UTC -4)
Sail Croatia…
[...]The facts talked about in the report are a number of the best available [...]…
olive garden coupons says:
November 29, 2012 at 9:20 pm (UTC -4)
olive garden coupons…
[...]Here are several of the sites we suggest for our visitors[...]…
negocios says:
November 29, 2012 at 10:12 pm (UTC -4)
negocios…
[...]just beneath, are various completely not associated web sites to ours, nonetheless, they are certainly really worth going over[...]…
Site says:
November 30, 2012 at 12:42 am (UTC -4)
Site…
[...]very few web-sites that happen to become comprehensive below, from our point of view are undoubtedly effectively worth checking out[...]…
Tacoma Injury Attorney says:
November 30, 2012 at 5:33 am (UTC -4)
Tacoma Injury Attorney…
[...]The data talked about in the post are some of the best offered [...]…
e cigarette reviews says:
November 30, 2012 at 12:44 pm (UTC -4)
get abuse from bullies. so it’s your…
job to keep them out.paying attention to your forum and keeping to these best practices will keep your forum active, friendly and attracting the right kind of visitors and new members. always use seo writing tips if you are having an…
Michele Kief says:
November 30, 2012 at 2:29 pm (UTC -4)
Michele Kief…
[...]we came across a cool web site that you may possibly get pleasure from. Take a appear when you want[...]…
data logger for temperature says:
November 30, 2012 at 2:36 pm (UTC -4)
data logger for temperature…
[...]we came across a cool web site that you just may take pleasure in. Take a search in the event you want[...]…
more says:
November 30, 2012 at 2:56 pm (UTC -4)
in nowadays world where people are also…
almost always busy, such a website where receiving donations system is incorporated into the website, makes it very easy and fast for people to give donations.i f you look at the most professional websites of the big npos like greenpeace usa,…
Mary Kay Intouch says:
November 30, 2012 at 3:11 pm (UTC -4)
Mary Kay Intouch…
[...]we prefer to honor many other online web pages around the internet, even though they aren?t linked to us, by linking to them. Below are some webpages really worth checking out[...]…
Internet Marketing Los Angeles says:
November 30, 2012 at 8:57 pm (UTC -4)
Internet Marketing Los Angeles…
[...]the time to read or visit the material or web-sites we have linked to below the[...]…
Check Out This Site says:
December 1, 2012 at 4:15 am (UTC -4)
Websites worth visiting…
[...]here are some links to sites that we link to because we think they are worth visiting[...]……
aed defibrillator says:
December 1, 2012 at 4:48 am (UTC -4)
Its hard to find good help…
I am constantnly proclaiming that its hard to get good help, but here is…
techniques in drawing says:
December 1, 2012 at 7:18 am (UTC -4)
Online Article……
[...]The information mentioned in the article are some of the best available [...]……
Explore Talent Videos says:
December 1, 2012 at 8:30 am (UTC -4)
Cool sites…
[...]we came across a cool site that you might enjoy. Take a look if you want[...]……
Ray Ban Aviator sunglasses says:
December 1, 2012 at 12:07 pm (UTC -4)
Ray Ban Aviator sunglasses…
[...]usually posts some pretty interesting stuff like this. If you?re new to this site[...]…
portal randkowy says:
December 1, 2012 at 7:47 pm (UTC -4)
Souls in the Waves…
Fantastic Early morning, I just stopped in to visit your web site and imagined I’d say I loved myself….
where to buy gold cheap says:
December 1, 2012 at 11:50 pm (UTC -4)
Links…
[...]Sites of interest we have a link to[...]……
Maryland Web Design says:
December 2, 2012 at 3:53 am (UTC -4)
Maryland Web Design…
[...]Every as soon as in a whilst we choose blogs that we read. Listed beneath are the most recent websites that we choose [...]…
futures & options trading says:
December 2, 2012 at 5:47 am (UTC -4)
Websites you should visit…
[...]below you’ll find the link to some sites that we think you should visit[...]……
drukarka fiskalna says:
December 2, 2012 at 7:06 am (UTC -4)
Recommeneded website…
below you’ll find the link to some sites that we think you should visit…
drukarek fiskalnych says:
December 2, 2012 at 7:46 am (UTC -4)
Nice website…
Found this yesterday and it’s great…
kasy fiskalne poznań says:
December 2, 2012 at 7:48 am (UTC -4)
Check this out…
Here are some of the sites we recommend for our visitors…
drukarki fiskalne warszawa says:
December 2, 2012 at 8:30 am (UTC -4)
Recommeneded websites…
Here you’ll find some sites that we think you’ll appreciate, just click the links over…
drukarki says:
December 2, 2012 at 9:11 am (UTC -4)
Mustread!…
Very relevenat to what I do myself…
golfudstyr says:
December 2, 2012 at 9:13 am (UTC -4)
excellent manual…
This may be the great significant excellent and helpful minimum data. I come to be able to feel glad that you choose to shown it ideas close to. Satisfy keep america existing this specific fit this explanation. Many thanks a good deal created pertainin…
kasa fiskalna warszawa says:
December 2, 2012 at 11:21 am (UTC -4)
The one…
One of the greatest articles I’ve ever found…
drukarki fiskalne poznań says:
December 2, 2012 at 5:54 pm (UTC -4)
Great website…
Here are some of the sites we recommend for our visitors…
darmowy serwis randkowy says:
December 2, 2012 at 6:13 pm (UTC -4)
The Absent Game…
Among me and my husband we’ve owned much more MP3 gamers over time than I can count, which includes Sansas, iRivers, iPods (classic & touch), the Ibiza Rhapsody, etc. But, the last few decades I’ve settled down to one line of players….
kasom fiskalnym says:
December 2, 2012 at 6:20 pm (UTC -4)
Check this out…
Here are some of the sites we recommend for our visitors…
kasy says:
December 2, 2012 at 7:28 pm (UTC -4)
Mustread!…
Very relevenat to what I do myself…
strona z randkami says:
December 2, 2012 at 9:07 pm (UTC -4)
Souls in the Waves…
Good Early morning, I just stopped in to visit your site and considered I’d say I liked myself….
The Hearing Fix says:
December 2, 2012 at 11:48 pm (UTC -4)
The Hearing Fix…
[...]always a significant fan of linking to bloggers that I like but do not get lots of link like from[...]…
opprette as says:
December 3, 2012 at 3:19 am (UTC -4)
opprette as…
[...]very handful of sites that come about to become comprehensive beneath, from our point of view are undoubtedly well really worth checking out[...]…
odzyskiwanie danych wrocław says:
December 3, 2012 at 7:16 am (UTC -4)
Website worth visiting…
below you’ll find the link to some sites that we think you should visit…
randki says:
December 3, 2012 at 7:29 am (UTC -4)
Thorn of Girl…
Superb information is usually uncovered on this website website….
kołobrzeg says:
December 3, 2012 at 9:08 am (UTC -4)
Check this out…
Here are some of the sites we recommend for our visitors…
affordable search engine optimization says:
December 3, 2012 at 11:04 am (UTC -4)
affordable search engine optimization…
[...]please check out the web-sites we adhere to, like this 1, because it represents our picks from the web[...]…
odzyskiwanie danych wrocław says:
December 3, 2012 at 11:32 am (UTC -4)
The one…
One of the greatest articles I’ve ever found…
dog and puppy training says:
December 3, 2012 at 8:20 pm (UTC -4)
dog and puppy training…
[...]Every the moment inside a although we select blogs that we study. Listed below would be the latest web sites that we choose [...]…
making money system says:
December 3, 2012 at 8:30 pm (UTC -4)
making money system…
[...]please go to the web sites we adhere to, like this one particular, as it represents our picks in the web[...]…
overcoming objections says:
December 4, 2012 at 4:36 am (UTC -4)
Informative and precise…
Its difficult to find informative and accurate information but here I noted…
proactol in stores says:
December 4, 2012 at 9:34 am (UTC -4)
proactol in stores…
[...]although websites we backlink to below are considerably not connected to ours, we really feel they are basically really worth a go by, so have a look[...]…
seo toronto says:
December 4, 2012 at 11:40 am (UTC -4)
seo toronto…
[...]Sites of interest we’ve a link to[...]…
wedding planning las vegas says:
December 4, 2012 at 2:13 pm (UTC -4)
400 to 500 words. the average reader…
loses interest in what they are reading after 400 words; therefore, rambling for 750 words is not going to keep readers coming back for more. the best blogs are precise, short, simple and attractive to readers.know your readersblogs have a specific…
amedeo maffei corsi says:
December 4, 2012 at 3:21 pm (UTC -4)
amedeo maffei corsi…
[...]although internet websites we backlink to below are considerably not related to ours, we feel they may be essentially really worth a go by way of, so have a look[...]…
My Homepage says:
December 4, 2012 at 4:01 pm (UTC -4)
… [Trackback]…
[...] Read More here: blog.wppionline.com/2012/03/21/mirrorless-lenses/ [...]…
« Previous 1 ... 33 34 35 36 37 ... 67 Next »